Research geared to easy storage of wet distillers grains |

Research geared to easy storage of wet distillers grains

NORTH PLATTE, Neb. – University of Nebraska-Lincoln research indicates that wet distillers grains are easier to store than most people might expect. Distillers grains is a good source of protein and energy and there’s an opportunity to use it economically on the ranch, said Aaron Stalker, beef extension specialist. If historic seasonal price patterns continue, livestock producers will be able to buy wet distillers grains in summer when they’re least expensive for feeding in winter when there’s a protein deficiency.

As pasture rent continues to increase and, at the same time, distillers grains become more available, the price of distillers should become more economical, Stalker said. He believes the two cost curves will cross so it’s less expensive to feed distillers grains with a poor-quality forage than to rent pasture.

“We also think that there’s potential for this to be a drought management strategy,” he said. “Distillers grains will be a substantive feed to make up for the lack of forage in a drought situation.”

Stalker said that some research at the Gudmundsen Sandhills Laboratory near Whitman is geared toward finding the most effective combination of poor-quality forage and distillers grains to make a ration that producers can feed out in the pasture. Stalker is aiming for a ration that can make up half the cow’s daily intake while cattle are on grass.

“That way we can put twice as many cattle in the same pasture without damaging range health,” Stalker said.

Stalker said that the water in the wet distillers grains offers a big challenge because it’s very expensive to transport. Another drawback is that most ranches don’t have the equipment to handle wet distillers grains. Distillers also has a relatively short shelf life. Research will investigate ways to overcome all those obstacles.

Stalker’s had good success with homemade bunkers using round bales and plastic or ground hay used to cover the bunker. Early results show that after about two weeks the grains start to mold, but the mold is not harmful to cattle.

A big concern with moldy corn is aflatoxins. Although further studies need to be done, neither aflatoxin nor any other micotoxin has been found in stored distillers grainsin concentrations great enough to be of concern in any of the samples Stalker has analyzed. Cattle readily eat stored distillers without adverse effects.

Stalker hopes that continued investigation of distillers grains in cattle rations will provide producers with an inexpensive, high protein and high energy feed.


Equine neurologic case investigation in Weld County


BROOMFIELD, Colo. — The Colorado Department of Agriculture State Veterinarian’s Office was recently notified of an equine neurologic case in Weld County. The State Veterinarian’s Office has been collaborating with the Colorado State University Veterinary…

See more


Start a dialogue, stay on topic and be civil.
If you don't follow the rules, your comment may be deleted.

User Legend: iconModerator iconTrusted User